Back to all

A Door No One Can Step Through (Fuel Door Repair and Maintenance)

September 3, 2023

Your vehicle has lots of doors including that one usually near the back on the vehicle's side.  That's the fuel door, something you use every time you gas up.  These endure hundreds of open-and-close cycles, usually without any problems.  But when they act up, it can be a major inconvenience for you.

When they stick in the "open" position, it can present real dilemma.  You can still pump your gas, but do you just drive around with that flap sticking out the side? What happens if someone steals the gas cap or it gets damaged? What happens if it rains? Yep, it's decision time.

A fuel door that sticks open can be due to a number of factors.  The hinge on the door may have broken, possibly from corrosion or it may have been hit sometime.  Some vehicles have a cable that operates the door and it could be loose.  The latch that holds the door shut could have broken or it, too, could be bent from something hitting it. 

You probably want to take care of this sometime soon since your gas cap is wide open and unprotected when the door doesn't shut.  Plus, it's possible that the door could be torn off completely.  Often a stuck open fuel door can be fixed fairly inexpensively and quickly depending on the type of mechanism your vehicle has. Looks like it's an open and shut case.

Tuffy Lehigh Acres
1209 Homestead Rd. N
Lehigh Acres, FL 33936
239-303-0033

More articles from Tuffy Lehigh Acres

Bad Vibes

September 14, 2025

Your vehicle has a way of letting you know when something's wrong. Consider a vibrating steering wheel. It certainly didn't do that when it was new, so that shake is trying to tell you something. There are a few things that can cause your steering wheel to vibrate as you drive down the road. One... More

Singing a Different Tune (Up) (Tune Ups)

September 8, 2025

Engines required a lot more maintenance in earlier times. You'd have to have your spark plugs, wires, rotors, caps, distributor points, fuel and air filters changed periodically. There were mechanical adjustments of a vehicle's timing, dwell, spark gap and idle mixture, too. Unless you like to ... More

The Light Nobody Wants to See (Check Engine Light)

September 1, 2025

You've probably had your Check Engine Light go on. Then it goes off and you figure, hey, whatever the problem was, it's gone now and I don't have to worry about it. Well, the problem may have gone away and it may not have. Your vehicle likely has one of these warning lights on the instrument pa... More